Catalytic ozonation of azo dye Reactive Red 120 in the presence of MgO nanoparticles
26 January 2017
چکیدهBackground and Aims: Dyes are widely used in different industries and consequently are disposed through different industrial effluents into the environment. Chronic and/or acute effects of the chemicals on microorganisms have been documented. Dyes may absorb and reflect the entering sun lights into the water and thereby decrease the algal photosynthesis. The later in turn can affect the food chain seriously. The aim of this study was, therefore, to use MgO nanoparticles as catalyst in heterogenic catalytic ozonation process (COP) for reactive red 120 dye removal (decolorization) from synthetic wastewater.
Materials and Methods: MgO nanoparticles were produced by sol-gel method. The influences of several operational parameters including solution pH, reaction time, MgO dosage and initial dye concentration on removal (decolorization) efficiency were evaluated.
Results: The optimum pH and MgO dosage for COP were determined as 10 and 3 g/L, respectively. Decolorization of 500 mg/L of dye was almost complete after 12 min under achieved optimum conditions. MgO nanocrystals markedly affected the COP and enhanced the dye removal efficiency by approximately 49% compared with the sole ozonation process.
Conclusion: Higher O3 decomposition in presence a small amounts of catalyst and alkaline pH increases the radical production which in turn improves the decolorization efficiency. Increasing the initial concentration of dye deteriorated the removal efficiency; however, this can be compensated by increasing the ozonation rate.
Key words: Catalytic Ozonation, MgO Nanoparticles, Reactive Red 120 dye (RR120).
Celekli A, Yavuzatmaca M, Bozkurt H. Kinetic and equilibrium studies on the adsorption of reactive red 120 from aqueous solution on Spirogyra majuscula. Chemical Engineering Journal 2009; 152: 7.
Senthilkumar S. Adsorption of dissolved Reactive red dye from aqueous phase onto activated carbon prepared from agricultural waste. Bioresource Technology 2006; 97(14): 1618-25.
. Absalan G. Removal of reactive red-120 and 4-(2-pyridylazo) resorcinol from aqueous samples by Fe3O4 magnetic nanoparticles using ionic liquid as modifier. Journal of Hazardous Materials 2011; 192(2): 476-84.
. Moussavi G, Mahmoudi M. Removal of azo and anthraquinone reactive dyes from industrial wastewaters using MgO nanoparticles. Journal of Hazardous Materials 2009; 168(2–3): 806-12.
. Saharan V.K, Badve M.P, Pandit A.B. Degradation of Reactive Red 120 dye using hydrodynamic cavitation. Chemical Engineering Journal 2011; 178(0): 100-7.
Oturkar C.C. Mechanistic investigation of decolorization and degradation of Reactive Red 120 by Bacillus lentus BI377. Bioresource Technology 2011; 102(2): 758-64.
Xue Y, Hou H, Zhu S. Adsorption removal of reactive dyes from aqueous solution by modified basic oxygen furnace slag: Isotherm and kinetic study. Chemical Engineering Journal 2009; 147(2–3): 272-9.
. Daskalaki V.M. Degradation of Reactive Red 120 using hydrogen peroxide in subcritical water. Desalination 2011; 274(1–3): 200-5.
. Arıca M.Y, Bayramoğlu G. Biosorption of Reactive Red-120 dye from aqueous solution by native and modified fungus biomass preparations of Lentinus sajor-caju. Journal of Hazardous Materials 2007; 149(2): 499-507.
0. Robinson T. Remediation of dyes in textile effluent: a critical review on current treatment technologies with a proposed alternative. Bioresource Technology 2001; 77(3): 247-55.
1. Hammad Khan M, Jung J.Y. Ozonation catalyzed by homogeneous and heterogeneous catalysts for degradation of DEHP in aqueous phase. Chemosphere 2008; 72(4): 690-96.
2. Harrelkas F. Photocatalytic and combined anaerobic–photocatalytic treatment of textile dyes. Chemosphere 2008; 72(11): 1816-22.
3. Sarayu K, Swaminathan K, Sandhya S. Assessment of degradation of eight commercial reactive azo dyes individually and in mixture in aqueous solution by ozonation. Dyes and Pigments 2007; 75(2): 362-68.
4. Wijannarong S. Removal of reactive dyes from textile dyeing industrial effluent by ozonation process. APCBEE Procedia 2013; 5: 279-82.
5. Sancar B, Balci O. Decolorization of different reactive dye wastewaters by O3 and O3/ultrasound alternatives depending on different working parameters. Textile Research Journal 2013; 83: 574-590
6. Moussavi G. Mahmoudi M. Degradation and biodegradability improvement of the reactive red 198 azo dye using catalytic ozonation with MgO nanocrystals. Chemical Engineering Journal 2009; 152(1): 1-7.
7. Erol F, Özbelge T.A. Catalytic ozonation with non-polar bonded alumina phases for treatment of aqueous dye solutions in a semi-batch reactor. Chemical Engineering Journal 2008; 139(2): 272-83.
8. He K. Catalytic ozonation of phenol in water with natural brucite and magnesia. Journal of Hazardous Materials 2008; 159(2–3): 587-92.
9. Liotta L.F. Heterogeneous catalytic degradation of phenolic substrates: Catalysts activity. Journal of Hazardous Materials 2009; 162(2–3): 588-606.
0. Zeng Y.-F, Liu Z-L, Qin Z-Z. Decolorization of molasses fermentation wastewater by SnO2-catalyzed ozonation. Journal of Hazardous Materials 2009 162(2–3): 682-87.
1. Sui, M. Heterogeneous catalytic ozonation of ciprofloxacin in water with carbon nanotube supported manganese oxides as catalyst. Journal of Hazardous Materials 2012; 227–228(0): 227-36.
2. Pawlowski L. Standard methods for the examination of water and wastewater, 18th edition: Arnold E. Greenberd, Lenore S. Clesceri, Andrew D. Eaton (Editors) Water Environment Federation, Alexandria, USA, 1992; 1025 pp; US$120 (Hardcover); ISBN 0-87553-207-1. Science of The Total Environment, 1994. 142(3): p. 227-28.
3. Gonçalves A.G, Órfão J.J.M, Pereira M.F.R. Catalytic ozonation of sulfamethoxazole in the presence of carbon materials: catalytic performance and reaction pathways. Journal of Hazardous Materials 2012; 239:167-74.
4. Joshi R. Free radical scavenging behavior of folic acid: evidence for possible antioxidant activity. Free Radical Biology and Medicine 2001; 30(12): 1390-99./26
5. Dao Y.H, De Laat J. Hydroxyl radical involvement in the decomposition of hydrogen peroxide by ferrous and ferric-nitrilotriacetate complexes at neutral pH. Water Research, 2011; 45(11): 3309-17.
6. Ma J, Graham N.J. Degradation of atrazine by manganese-catalysed ozonation influence of radical scavengers. Water Research 2000; 34(15): 3822-28.
7. Sánchez-Polo M, Rivera-Utrilla J, Von Gunten U. Metal-doped carbon aerogels as catalysts during ozonation processes in aqueous solutions. Water Research 2006; 40(18): 3375-84.
8. Matatov-Meytal Y. Cloth catalysts in water denitrification: I. Pd on glass fibers. Applied Catalysis B: Environmental 2000; 27(2): 127-35.
9. Kasprzyk-Hordern B, Ziółek M, Nawrocki J. Catalytic ozonation and methods of enhancing molecular ozone reactions in water treatment. Applied Catalysis B: Environmental 2003; 46(4): 639-69.
0. Valdés H, Zaror C.A. Heterogeneous and homogeneous catalytic ozonation of benzothiazole promoted by activated carbon: Kinetic approach. Chemosphere 2006; 65(7): 1131-36.
1. Valdés H. Catalytic ozone aqueous decomposition promoted by natural zeolite and volcanic sand. Journal of Hazardous Materials 2009; 165(1): 915-22.
2. Zhao L. Enhancement mechanism of heterogeneous catalytic ozonation by cordierite-supported copper for the degradation of nitrobenzene in aqueous solution. Environmental science & technology 2009; 43(6): 2047-53.
3. Kermani M. Degradation efficiency and kinetic study of metronidazole by catalytic ozonation process in presence of mgo nanoparticles. urmia medical journal 2013; 24(10): 839-50.
4. De W. Ozonation and advanced oxidation by the peroxone process of ciprofloxacin in water. Journal of Hazardous Materials 2009; 161(2): 701-08.
5. Dewitte B. Ozonation of ciprofloxacin in water: HRMS identification of reaction products and pathways. Environmental science & technology 2008; 42(13): 4889-95.
6. Bahramil F. Removal of Metronidazole from Aqueous Solution Using Ozonation Process. Journal of Mazandaran University of Medical Sciences 2015; 25(121): 11-20.
7. Valdes H. Heterogeneous catalytic ozonation of benzothiazole aqueous solution promoted by volcanic sand. Journal of Hazardous Materials 2008; 153(3): 1036-42.
8. Ernst M, Lurot F, Schrotter J. Catalytic ozonation of refractory organic model compounds in aqueous solution by aluminum oxide. Applied Catalysis B: Environmental 2004; 47(1): 15-25.
- چکیده مشاهده شده: 377 بار
- PDF (English) دانلود شده: 129 بار