Measurement of mass emission values of gaseous pollutants from the stack of Doroud Cement Plant

Yusef Omidi Khaniabadi, Rajab Rashidi, Gholamreza Godarzi, Soudabe Zare

194

Abstract

Background and Aims: Cement industries are known as one of the important sources of air pollution especially hazardous gases. Although several samples have been taken from stacks by environmental experts, accurate assessment of pollutant emissions, which can be used as basic modeling of air pollution and managing, is not available. The purpose of this study is to measure and investigate gases volumetric concentrations from stack of Doroud Cement Plant and finally compare with standards.
Materials and Methods: The volumetric concentrations of gases (ppm) measured by Testo XL350 during a period of six months. After standardization of pressure and temperature on the ideal gas law, the detected values were converted to mass concentrations and then gases mass emission (g/s) was computed considering the stack flow.
Results: Results showed that detected pollutants’ volumetric concentrations were higher than their standard levels for stack cement industrials (Electro Filter and Pre-heater). It has also been found that due to the use of oil fuel as a kiln fuel, the emissions of CO and SO2 gases increased in winter.
Conclusion: This method can be applied as a model for gas emission. Long distance detection of gas pollutants should be considered for environmental monitoring of pollutants around cement industries.
Key words: Mass emission, Pollutant gases, Doroud Cement Plant

Full Text:

PDF

References

Boudaghpour S, Jadidi A. Investigation of the effect of outlet pollutants of cement production Industries around Tehran and approaches to control and eliminate pollutants. Intl J Phy Sci 2009;4(9):486-95.

Shirazi H, Yadghar A. Modeling and analyze dispersion of emission pollutants from air pollution mobile sources based on GIS case study: Tehran city. Tehran Air Pollution Control Projects 1383.

Naddafi K, Heydari M, Hasanvand M, Qaderpour M. A comparative study of Tehran air quality in 2006 to 2007,11th Hamayeshe mohite behdashte; Zahedan2008. p. 46-7.

Ghiasedin M. Sanitary affects air pollution, air and sound pollution in law Iran. Tehran: Studies & Schematization Center Publications; 2008.

Gurjar B, Butler T, Lawrence M, Lelieveld J. Evaluation of emissions and air quality in megacities. Atmospheric Environment 2008;42(7):1593–606.

Mwaiselage J, Bratveit M, Moen B, Yost M. Variability in dust exposure in a cement factory in Tanzania.Ann Occup Hyg. 2005;49(6):511-9.

Conneely D, Gibbs M, Soyka P. CO2 emissions from Cement Production. Good Practice Guidance and Uncertainty Management in National Greenhouse G as Inventories2001.

Atkinson R, Anderson H, Strachan D, Bland J, Bremmer S, Ponce de Leon A. Short-term Associations between outdoor air pollution and visits to accident and emergency department s in London for respiratory complaints. Eur Respir J 1999;13:257-65.

Woodard F. Industrial Waste Treatment Handbook. USA: Butterworth–Heinemann 2001.

Chang M, Ch ung Y, Kwon S. A Study on the emission and dispersion of particulate Mather from a CementدPlant. Korean J Prev Med. 1983; 16(1): 67-77.

/42

Moatar F. The effects of environmental pollution from the perspective of Ilam cement Environmental Engineering Master's thesis 2004; 3-30.

Al-Smadi M, A l-Zboon K, Shatnaw M. Assessment of Air Pollutants Emissions from a Cement Plant: A Case Study in Jordan. Journal of Civil Engineering 20 06; 3(3): 265-82.

Chavoshi B, Massoudinjad M, Adibzadeh A. Evaluation the Amount of Emission and Sulfur Dioxide Emission Factor from Tehran Oil Refinery. Journal Health & Environ 2011;4(2):233-44.

Wark K, Warner C, Davis W. Air Pollution: Its Origin and Control. 3rd ed. New York: Addison-Wesley; 1998.

Colls J. Air pollution.2 Edition. London: Spon press; 2002.

Almasi A, Asadi F, Mohamadi M, Farhadi F, Atafar Z, Khamutian R, et al. Survey of Pollutant emissions from stack of Saman ce ment factory of Kermanshah city from year 2011 to 2012. Journal of Health's in The Field 2013;1(2):36-44.

Daraie H, Motasadi Zarandi S, Piraste M. Study of monitoring, maintenance, and problems of electrostatic precipitators in some cement plants in Iran. Knowledge Horizons. Journal of the Medical and Health Sciences University Gonabad 2011;3(17):66-74.

Abu-Allaban M A-QH. Impact Assessment of Ambient Air Quality by Cement Industry: A Case Study in J ordan. Aerosol and Air Quality Research 2014;11:802-10.

Refbacks

  • There are currently no refbacks.